2009 CATERPILLAR 329DL
- Share this item:
- Call: +1 877 228 3512
AIR CONDITIONER; STICK, MEDIUM; CARBODY, STANDARD; PRODUCT LINK; HAND AND FOOT CONTROL; LIGHTING; STRAIGHT TRAVEL PEDAL; PRODUCT LINK; ; OVERALL RATING: FAIR, Model: 329DL
- Click here for more information
- $111,500.00 USD
- NORTON, VA USA
|New Very Good Good Fair Poor|
Cleaning RequiredMachine cleaned and the cab
NotesMachine cleaned as well as the cab
Car BodyThere are four foot long cracks underneath the car body where it welds to the roller frame on both sides.
Eng. Enclose Hood / Stack
Engine DoorsDamage on the left rear (radiator) door.
FendersRight front storage box door latch will not work.
Grab IronsLeft front cab handrail bent. Right front handrail bent.
HoodThe hood is damaged.
Main Frame Welds
Radiator Grill & Shroud
Sheet MetalDamage on right front fuel tank cover.
Steps / LadderThe right front step is bent. Three of the roller frame steps are home made.
Safety Decals In PlaceNo
HornDoes not work. Need to troubleshoot.
GAUGES, OPERATOR STATION, CONSOLE
Air ConditionerDoes not work. Need to troubleshoot.
EMS Panel / Warnings
MeterService meter has been replaced. Currently showing 216.3 hours.
Seat Beltreplaced 9/29/2015
Seat Cushion / Arm RestTop seat cushion torn.
Back Up Alarm
Current Parts Manual
Current Safety Manual
Air CleanersAir filters are dirty.
Belts / Pulleys
Exhaust / Muffler
Fuel Injection System
Turbocharger / Blower
Compression in Radiator
Fluid Levels OK?Need to add coolant.
Oil LeaksValve cover and rocker box leaking.
Water in Oil
Oil Pressure (H/L/N)Normal
Radiatorreplaced radiator cap
ELECTRICAL, STARTING AND CHARGING SYSTEM
Ether AidStart aid tube broken.
Batteries / Cables4 new batteries installed
Swing Drive Oil LevelOK
Boom CylinderLeft lift cylinder is leaking oil around rod seal.
Bucket CylinderClamps that retain the tube to the cylinder is missing.
Control LinkageExcessive wear / movement in the bucket linkage / pins.
Operating ConditionHydraulic oil temperature sensor "voltage below normal" code is active.
Pumps & ValvesHydraulic oil leaks around center section. Need to remove covers to check further.
Travel MotorsThe right side will not tram at times and is very slow. Need to troubleshoot.
Boom Length (Actual Length)20 foot 2 inches
Boom PinsSlight wear on pins. Some side to side movement.
Pins & Bushings
Stick Length10 feet and 6 inches
Pins & BushingsThe stick to bucket movement has 3/4" movement / wear. See "bucket linkage" for pricing.
Stick ConditionsBent in on the bottom. There is excessive slack between the sides of the stick and the bucket - excessive side to side movement.
Stick PinsSlight wear on pins / bearings. some side to side movement.
Quick Coupler (Make/Model)N/A
Bucket LinkageExcessive wear and movement in pins, linkage and bearings. Some broken bolts in the pin retainers.
Bucket MountsCracks on top left of the bucket.
Bucket SidesThe sides of bucket are separating from the bottom of the bucket. Plate over bucket sides.
Teeth / Adapters
Link Part NumberAfter market track.
Track Frame - LeftThere are three bottom roller bolts broken.
Track Frame - Right
Average Life RemainingTrack - 63%, Idlers - 62%, Rollers - 64%
NotesThree rollers on the left side are worn too bad to measure.
|Measure (L)||Measure (R)||% Worn (L)||% Worn (R)||Potential Hrs (L)||Potential Hrs (R)|
|Carrier Rollers Front||156 mm||135 mm||32||120|
|Carrier Rollers Rear||157 mm||158 mm||24||16|
|Idlers Front||23 mm||21 mm||52||24|
|Links||114 mm||114 mm||16||16|
|Pins & Bushings (External)||63 mm||63 mm||36||36|
|Pins & Bushings (Internal)||812 mm||812 mm|
|Track Roller 1||16 mm||18 mm||8|
|Track Roller 2||18 mm||18 mm||8||8|
|Track Roller 3||18 mm||18 mm||8||8|
|Track Roller 4||20 mm||20 mm||40||40|
|Track Roller 5||18 mm||18 mm||8||8|
|Track Roller 6||17 mm||18 mm||8|
|Track Roller 7||N/A||20 mm||40|
|Track Roller 8||N/A||18 mm||8|
|Track Roller 9||N/A||17 mm|
|Track Shoes (Width)||31 1/2"||31 1/2"|
Pins & Bushings Turned?No
Planetaries / Diff
COMMENTS, MISC. REPAIRS, GENERAL REMARKS
New radiator cap installed
Machine cleaned and the cab
4 new batteries installed
New seat belt installed 9/29/2015